Volkswagen Routan Reliability by YearBest & worst years, problems & recalls — NHTSA data

VEHICLE WOULD SHUDDER SOMETIMES HARSHLY UNDER LIGHT THROTTLE AT 45-60MPH AND SMALL HILL OR ACCELERATION. DEALER DIAGNOSED A LEFT CYLINDER HEAD FAILURE AND CYLINDER MISFIRES. VEHICLE HAS APPROXIMATELY 80,000 MILES. NOT INCLUDED BY VIN AND FALLS JUST OUTSIDE THE MANUFACTURING DATE, WHICH RESULTED IN A MANUFACTURERS EXTENDED WARRANTY FOR SIMILAR FAILURES. REQUESTED ASSISTANCE FROM VW DUE TO THE SIMILARITY OF FAILURE AND CLOSE MANUFACTURING DATE FOR THE EXTENDED WARRANTY. VW DID NOT OFFER ASSISTANCE. HARD TO BELIEVE A VEHICLE JUST PRODUCED OUTSIDE AN EXTENDED WARRANTY WINDOW WOULD HAVE A SIMILAR FAILURE AND NOT BE A PART OF THE EXTENDED WARRANTY. REVIEW THE DOCUMENTED COMPLAINTS... MANY 2013 DODGE GRAND CARAVAN, CHRYSLER TOWN AND COUNTRY AND VW ROUTAN VANS HAVE LEFT CYLINDER HEAD FAILURES THAT ARE DOCUMENTED YET ARE NOT INCLUDED BY THE MANUFACTURERS IN THEIR EXTENDED WARRANTY NOTICE.

TL* THE CONTACT OWNS A 2013 VOLKSWAGEN ROUTAN. WHILE DRIVING UNKNOWN SPEEDS, THE VEHICLE SHOOK, JERKED, AND MISFIRED WHILE THE ACCELERATOR PEDAL WAS APPLIED. THE VEHICLE WAS TAKEN TO A LOCAL DEALER (HAWK VOLKSWAGEN LOCATED AT 2861 W JEFFERSON ST JOLIET, IL 60435 815-741-1100) WHERE IT WAS DIAGNOSED THAT THE CYLINDER HEAD NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT DID NOT OFFER ANY ASSISTANCE. THE FAILURE MILEAGE WAS 74,000.

ENGINE WON'T START WHEN BRAKE PEDAL IS DEPRESSED WHILE VAN IS PARKED IN DRIVEWAY, GARAGE, AT GAS STATION, AT SORE PARKING LOT; ALARM HORN SOUNDS FOR NO REASON WHEN VAN IS PARKED; DOORS LOCK WHEN EXITING VEHICLE YET NO LOCK/FOB HAS BEEN PRESSED LOCKING BOTH ELDERLY PARENTS INSIDE VAN WHEN TEMPS. WERE -5 DEGREES OUTSIDE; ENGINE ONLY STARTS WHEN REMOTE START BUTTON ON KEY FOB IS USED, THEN THE ALARM HORN SOUNDS UNTIL VAN IS TURNED OFF AND RESTARTED. THE ISSUE IS CLEARLY THE T.I.P.M. MODULE WHICH HAS BEEN AN ISSUE ON SEVERAL CHRYSLER-BASED PRODUCTS (WHICH THIS ROUTAN IS.) VW HAS RUN DIAGNOSTIC CODES TWICE AND NOTHING TURNS UP BECAUSE THE VAN ISN'T RUNNING TO TRIGGER A CODE. ALTHOUGH I HAVE AN EXTENDED WARRANTY, THEY SAY THE T.I.P.M. IS NOT COVERED BECAUSE NO CODES ARE TRIGGERED. MANUFACTURER COMMUNICATION NO.: TB-15-11-04. NHTSA NUMBER: 10043276. THE DATE LISTED BELOW (01/06/2015) IS THE FIRST INSTANCE OF ENGINE FAILURE, IT HAS BEEN ONGOING AS OF LAST WEEK, 7/6/2016.

Driver steering wheel airbag deployed while parking van at work. Nothing was hit just went off causing burns and wrist pain and swelling. Wife stated that the front windshield wipers started turning on randomly while driving to work and then airbag blew while parking.

My vehicle is shutting off while driving. It randomly shuts off and I see there are other recalls associated with this issue for a different year but same vehicle/model. I am being quoted well over $2,000 in repairs. This vehicle only has 130,000 miles on it.

At first it starts off the vehicle will just shut off while you are driving which is very dangerous I have read many people complaining about this it needs to be recalled then the brakes go and then the transmission seal I have done all the maintenance up keep on my vehicle there is no reason for the vehicle did you shut off the way it keeps shutting off and dying for no reason the battery keeps dying by the next morning when nothing is left on in the vehicle it has caused me a great deal of grief and it is very scary when you have children in the car and your vehicle just shuts off on the freeway when everything is electric guess what no breaks

NHTSA Recall 14v396 is probably the best correction to this issue. My van has shut off mid-driving while my children are in the car with me. It is so dangerous in the road. I can't move the steering wheel. Mechanics can't seem to diagnose the problem because the van doesn't give any computer codes when it would shut down. There are similar complaints and I wonder how Volkswagen knows of this issue and has failed to inform the owners of these vehicles. Chrysler had a similar issue and did a recall. I hope Volkswagen would acknowledge this issue.

Several times in the last month the car has stopped running without warning. It just shuts off. This has happened in our subdivision travelling at 20mph and most recently on the highway travelling 65mph. The power steering, brakes, everything go dead when the car just turns off and this could cause a serious accident.

On Thursday January 6, 2022, I took my car Volkswagen Routan 2012 to the service center because the check engine light went on and the engine revving. The service center took a week for diagnostic it, then they informed me on January 13, after charging me $180 that it needs a new transmission because it stuck in limp mode (see attached report). I asked the customer service to contact Volkswagen representative because this problem seems to be a manufacture problem, especially the car run less than 85000 miles and all maintenance service done on time with Volkswagen dealership. This mileages are considered very low to have a transmission problem with well maintained car. They took another three weeks to report me by phone that Volkswagen refused completely to take care or to share responsibility for this problem and they rejected my claim.  Because the claim runs by the dealership “service center” on behalf of me, I asked their customer service representative to email me what is Volkswagen final decision and why?  Three days later, the customer service told me by phone “it’s confidential” and they can not email me.

Car is stalling out while driving with no warning. Doesn't matter the rate of speed I'm going it just cuts out. Can't turn steering wheel. No codes pop up. No mechanics can pinpoint issue. I have seen quite a few thousand people complaining of the same issue and reported it to vw as well as nhtsa and NO ONE will do a recall. Chrysler did a recall for this same issue but NOT vw. This is a safety issue for not only the owner but other drivers on the road. If I get into an accident or cause one I WILL BE suing nhtsa as well as vw for no recall being done. I have printed out over 100 pages of complaints from others for evidence of complaints. I have already entered the class action lawsuit with others having the same issue. RECALL THE ISSUE OR FACE LAWSUITS.

The transmission on our 2012 VW Routan has completely failed. The car will not go into gear and left my wife in a position where she was stranded in traffic. We are the original owners of this vehicle and have followed the recommended maintenance schedule. The engine in this vehicle is a Chrysler Pentastar V6. (The vehicle was built as a joint venture between VW and Chrysler) According to online research Chrysler has recognized a “fatal flaw” in this engine and has extended warranty to customers in order to cover repairs beyond 100,000 miles. We only have 72,000 on our vehicle. I have spoken with VW North America, they told me to plead my case with Chrysler. I spoke with Chrysler and they told me to plead my case with VW. Neither company is willing to recognize that a total transmission failure at 72k miles is [their] responsibility. I am asking for the drivetrain warranty on our vehicle to be extended, due to the “fatal flaw” which has already been identified by Chrysler on the Pentastar V6. VW service is asking me to pay more than $6,000 to repair the vehicle.

The ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which then depowers various key safety systems including, but not limited to, air bags, power steering, and power braking. This has happened to me several times including while driving on the interstate and in traffic. I was able to pull over but it is very difficult when power steering and power breaking goes out. I had children in the vehicle several times when this has happened. Per Volkswagon website, I removed all keychains or anything that would cause the key fob to be weighed down. When I contacted them, they said my van is not under recall even though it is the same exact issue previous models had been recalled for. The only symptom prior was the check engine light was on.

referenced to recall nhsta Id no:11v-151 same issue happens on newer models, the car key ignition switch does not secure the key and that causes the car shut-down in tje middle of highway or road intermittently! ıt does not give any dashboard warning and no codes! all the lights are being gone and even ac shuts off! when ı push the key the lights come back on and the car can be turned on again. similiar problems are poster on youtube: https://youtu.be/ZESy-MnVPZs

The battery started dying randomly several months ago. I have called multiple dealerships and had diagnostics ran twice on the car. Initially I was told there is no draw on the battery. Then it was discovered that the TIPM module needs to be replaced. I then started researching this problem with this vehicle only to find multiple forums full of people having the same exact issue or worse! As in, their car stalls on the highway randomly while driving!! Someone could die! This module fails and in my case causes the fuel pump to continue running even when the car is off which completely drains the battery overnight! Chrysler (same manufacturer of this TIPM) already lost a class action lawsuit and recalled this TIPM but the Volkswagens affected by this same issue were not included leaving those of us now experiencing the same problem in a scary position because we can’t afford to get this fixed as it is very expensive let alone get a new car! It baffles me how well known it is that this part is the same part that’s been recalled but it doesn’t apply to this vehicle. On top of that, I called 3 Chrysler dealerships to explain the problem and was told they don’t work on this vehicle! This is unacceptable! I don’t know how the NHTSA has not done something about this! It seems several class action lawsuits need to filed! Hopefully before someone loses their life!