2019 Chevrolet Volt Problems
The 2019 Chevrolet Volt, with only 34 NHTSA complaints and 2 recalls, shows a mixed reliability picture for used-car buyers. Based on 34 real NHTSA owner complaints, with Transmission / Drivetrain the most reported area.
Before you buy
This 2019 Chevrolet Volt has 34 NHTSA complaints — top issue: Transmission / Drivetrain.
A model-year pattern isn't the car in front of you. Check this exact VIN for accidents, open recalls, odometer rollback, and salvage titles.
Free preview · Full report from $12.95.
2019 Chevrolet Volt Fuel Economy
✓ EPA Official DataEPA-rated energy efficiency for the 2019 Chevrolet Volt. Values shown in MPGe (miles per gallon equivalent).
Source: EPA FuelEconomy.gov. Figures reflect EPA lab testing; real-world results vary by driving style, load, and conditions.
2019 Chevrolet Volt Safety Ratings
NHTSA 5-Star ProgramOfficial crash test results from the NHTSA 5-Star Safety Ratings program. Stars reflect government-conducted tests; higher is safer.
Overall
9.3% rollover risk
Frontal Crash
Side Crash
Rollover
9.3% probability
Source: NHTSA 5-Star Safety Ratings. Ratings are based on government crash tests and may not reflect all trim levels.
CHEVROLET VOLT 2019 has 34 NHTSA complaints, with transmission/drivetrain issues (16) and electrical faults (11) most common. Two recalls were issued. Pre-purchase inspection is recommended. Source: NHTSA owner complaints and recall records.
- Make
- Chevrolet
- Model
- Volt
- Model year
- 2019
- NHTSA owner complaints
- 34
- Crash-related complaints
- 3
- Safety recall campaigns
- 2
- Top reported component
- Transmission / Drivetrain
- Reliability signal
- Severe Issues
- EPA MPGe combined
- 42
- EPA MPGe city / highway
- 43 / 42
- Fuel type
- Regular Gasoline
- Electric range (miles)
- 420
- NHTSA overall safety rating
- 5/5 stars
- NHTSA frontal crash rating
- 5/5 stars
- NHTSA side crash rating
- 5/5 stars
- NHTSA rollover rating
- 5/5 stars
- Electronic stability control
- Standard
Common problems
Most common 2019 Chevrolet Volt problems
Top owner-reported complaint areas and where they often appear.
Transmission / Drivetrain
Electrical Faults
Uncategorized Issues
Complaint patterns center on Transmission / Drivetrain, Electrical Faults, Uncategorized Issues. Use these as a pre-purchase inspection guide, then verify recall and damage history on the specific VIN.
Buyer verdict
Should you buy a used 2019 Chevrolet Volt?
The 2019 Volt may be worth considering if you find a well-maintained example, but the transmission and electrical complaint patterns warrant caution. Pre-purchase inspection is strongly advised.
Transmission and electrical issues can lead to costly repairs and reduced reliability, making pre-purchase inspection critical.
May Suit
This year may suit buyers who are willing to perform thorough due diligence and have access to a trusted mechanic.
May Want to Avoid
Buyers seeking maximum reliability with minimal risk of transmission or electrical problems should consider other years or models.
Pre-purchase
What to check before buying a used 2019 Chevrolet Volt
Inspection Focus
- Inspect transmission for slipping, hesitation, or unusual noises.
- Check all electrical systems, including infotainment and battery management.
- Verify brake system condition and performance.
Before You Close the Deal
- Obtain a professional transmission inspection.
- Verify all open recalls at nhtsa.gov/recalls.
- Request service records for transmission and electrical repairs.
- Have a mechanic inspect the vehicle before purchase.
Check the exact car
Shortlist with model-year data. Decide with the exact VIN.
Before buying a used 2019 Chevrolet Volt, run a VIN history report to verify accidents, title brands, odometer records, theft checks, and open recalls for the exact vehicle.
AI verdict
What the complaint data suggests
Editorial interpretation of NHTSA public complaint data. Source: nhtsa.gov. Complaints are owner-submitted and do not confirm a defect. Methodology
Based on NHTSA complaint data, the 2019 Chevrolet Volt has 34 total complaints, with the highest volume in Transmission/Drivetrain (16 complaints) and Electrical Faults (11 complaints). Two recalls were issued for this model year. Source: NHTSA owner complaints and recall records.
Year context: Compared to other model years, 2019 has a moderate complaint count, but transmission complaints are notably high.
Recall context: Two recalls indicate that verifying all recall repairs are completed is essential before purchase.
- Transmission/Drivetrain accounts for 16 of 34 total complaints.
- Electrical Faults account for 11 complaints.
- 3 crash-related complaints were reported.
- Transmission/Drivetrain issues are the most reported problem.
- Electrical Faults are the second most common complaint.
- Engine Problems and Brake System each have 3 complaints.
Full breakdown
All 2019 Chevrolet Volt complaints by category
Every owner-reported complaint category filed with NHTSA for the 2019 Chevrolet Volt. Use this as a pre-purchase inspection checklist.
| Component | Complaints | Crashes | Fires | Avg Mileage | Volume |
|---|---|---|---|---|---|
| Transmission / Drivetrain | 16 | 1 | — | — | |
| Electrical Faults | 11 | 2 | — | — | |
| Uncategorized Issues | 8 | — | — | — | |
| Engine Problems | 3 | — | — | — | |
| Brake System | 3 | 2 | — | — | |
| Fuel/Propulsion System | 2 | 1 | — | — | |
| Seat-Related Issues | 1 | — | — | — | |
| Steering Defects | 1 | — | — | — | |
| Unintended Acceleration | 1 | — | — | — | |
| Forward Collision Avoidance: AEB | 1 | — | — | — | |
| Electronic Stability Control (Esc) | 1 | — | — | — |
Source: NHTSA Complaints Database. Complaint counts may exceed total complaints because one report can span multiple categories.
In their words
Real owner complaints
Read what owners actually reported to NHTSA for the 2019 Chevrolet Volt. Type a keyword (e.g. “transmission”, “stalling”, “brakes”) to filter.
The contact owns a 2019 Chevrolet Volt. The contact stated that while the vehicle was shifted to park(P), the message to “Shift to Park” remained displayed. The contact was unable to turn off the vehicle. The contact stated that for approximately 10 minutes, the gear shifter was …
The contact owns a 2019 Chevrolet Volt. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the battery high-voltage disconnect relay. The vehicle was not repa…
When shifted into park, persistent error message that car was not in park. Unable to shut off the car despite numerous manipulations of shift. Few similar preceeding incidents were resolved by shift to drive then back to park. Goes to dealer tomorrow. Car running endlessly is dan…
Driver seat frame has a loud squeak during normal operation of vehicle. Driver seat is a critical safety item, and my concern is that the seat frame has a manufacturing defect.
Two incidents related to the powertrain. 1) In December, 2023, the EV battery was drained and the car would not start based on the gas motor. The dealer fixed it in our recollection. 2) On [XXX], I was driving the car out of a Detroit Convention Center parking lot, going up the …
Mileage: 38523 Engine Not Available Service Soon Propulsion Power Is Reduced Fuel Range Low: 3/4 Tank full of gas [XXX] - I was driving Northbound on [XXX] South of Castlewood in Northern California. I was driving 70 mph when I suddenly received the error messages above on my das…
While driving home one evening, the power steering suddenly failed. A warning message displayed to service the power steering. It became very difficult to steer the car. I had to pull extremely hard on the wheel to be able to make turns. For the turn into my community, I had to m…
Vehicle lost propulsion and all power mid turn at approximately 45mph. Powe steering and assisted brakes were gone. Conditions were rainy, resulting in single car crash. Car did not restart. No codes present. Occurred again after repairs at 70mph on highway. Codes P0AC4 and P0C0E…
I am getting "shift to park" error when turning off vehicle. Vehicle does not shut off--problem is defect in the transmission and apparently this is fairly common defect yet there is no recall???
Vehicle has developed an intermittent issue when placed in park. Displays a message "Attention Needed: Shift to Park" accompanied by audio alerts inside and outside of the vehicle. This is obviously unsafe as the vehicle cannot be parked and turned off reliably. GM Technical Bul…
I purchased this vehicle from East Bay BMW in Pleasanton, CA on April 8, 2023. On August 28, 2023, to September 4, 2023, I began to receive messages on the dashboard stating shift to park. The shift lever was in park but was not registering this. I had to wiggle the shift lever t…
This is a Legitimately Serious Concern regarding GM Vehicles (including Chevrolet) and Dealer Service Compliance with "Safety Warnings" and Reliability Warnings as in Factory Service Manuals. Specifically "Single Use Fasteners" and "Do Not Use Air-Impact on Brake System Fastene…
Started in late summer/fall of 2022 getting 'shift to park' error. The vehicle is in park and unable to turn off the vehicle when I get this error. I have noticed the error is more prone to come on when the parking break is also engaged or if it's on any sort of hill but I cann…
2019 Chevy Volt gave a Shift to Park message when vehicle was already in Park. Could not turn off vehicle. Had to restart Volt, then take out of park, but back in park and message disappeared and was able to safely leave vehicle.This happened approximately 6 times in one outing…
I was getting on the I15 freeway. After I entered, I set the cruise control and it immediately began to accelerate the vehicle to maximum speed. I was unable to turn it off and had to repeatedly push the brakes to keep the speed below 70 + mph. Smoke from the brakes began to …
Car just stops when the battery control module stops working. Potential to leave us stranded in traffic. Confirmed as a defective part by the dealer.
Intermittent shift to park message when in park. Unable to turn off vehicle.
Shift car issues. The car would not shut off because it doesn’t recognize that the gear is in parking.
Intermittently, the car would not turn off, starting in about July, 2022. After shifting the car into park and pressing the On/Off switch, the car displayed a message like "Action required. Shift to park". It was impossible to know if the car really was not in park, and would ro…
About half the time, when I put the vehicle into park, a warning comes up telling me that the vehicle is not in park. I can make the problem go away by wiggling the shift lever. But it is a recurring problem, and it is getting worse.
Source: NHTSA Complaints Database. Real owner reports for the 2019 Chevrolet Volt.
Safety recalls
2019 Chevrolet Volt recalls
2 campaignsNHTSA recall campaigns for the 2019 Chevrolet Volt. Two recalls indicate that verifying all recall repairs are completed is essential before purchase. Recalls are free to fix at authorized dealers, but completion status must be verified on the exact VIN.
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER
SEAT BELTS:REAR/OTHER
Research more
Keep researching before you buy
Compare brands and categories, then check the exact car's history by VIN.
Questions
2019 Chevrolet Volt buying FAQ
Buyer-focused answers based on real NHTSA complaint and recall data for this model year.
Is the 2019 Chevrolet Volt reliable?▾
Severe Issues. NHTSA currently shows 34 owner complaints, 3 crash-related complaints, and 2 recall campaigns for this model year. The 2019 Volt may be worth considering if you find a well-maintained example, but the transmission and electrical complaint patterns warrant caution. Pre-purchase inspection is strongly advised. Treat this as a model-year signal, then verify the exact vehicle's condition and history before purchase.
What are the most common problems with the 2019 Chevrolet Volt?▾
#1: Transmission / Drivetrain (16 complaints). #2: Electrical Faults (11 complaints). #3: Uncategorized Issues (8 complaints)
At what mileage do problems start on the 2019 Chevrolet Volt?▾
Mileage data is not available or insufficient for this model year.
How safe is the 2019 Chevrolet Volt?▾
Complaint data is not the same as crash-test scoring, but it does highlight possible risk patterns. For the 2019 Chevrolet Volt, NHTSA complaints include 3 crash-related reports and 0 fire reports out of 34 total complaints. 1 injury reports are also on file. For controlled crash-test ratings, check nhtsa.gov/ratings.
Does the 2019 Chevrolet Volt have any recalls?▾
Yes. 2 NHTSA recall campaigns affect the 2019 Chevrolet Volt. A major recall area is SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER. Two recalls indicate that verifying all recall repairs are completed is essential before purchase. Always verify open recalls by VIN because completion status varies by vehicle.
Should I buy a 2019 Chevrolet Volt?▾
The 2019 Volt may be worth considering if you find a well-maintained example, but the transmission and electrical complaint patterns warrant caution. Pre-purchase inspection is strongly advised. Transmission and electrical issues can lead to costly repairs and reduced reliability, making pre-purchase inspection critical. Pay extra attention to Transmission / Drivetrain during inspection. Before committing, run a VIN history report to verify accidents, title brands, odometer records, and recall completion for the exact car.
Source: NHTSA (National Highway Traffic Safety Administration) complaint and recall databases, aggregated by VinSpectorAI.
Wider context: See the full Chevrolet Volt reliability report with year-by-year comparison.
Owner Reliability Rating
Rate the 2019 Chevrolet Volt based on your ownership experience.
Add your rating:
Ratings are based on owner experience and are separate from NHTSA data shown above.
Before you buy
Check the exact vehicle history before you buy
Model-year complaints and recalls reveal patterns. A VIN report confirms whether the exact car has accident history, title brands, mileage issues, or open recalls.