Head-to-head reliability
Chevrolet HHR vs FORD F 150
How the Chevrolet HHR and FORD F 150 compare on NHTSA complaints, recalls and crash reports — and which is the lower-risk used buy.
Based on NHTSA owner-complaint & recall records
Chevrolet HHR averages fewer NHTSA complaints per year. Chevrolet HHR has 3,574 complaints and 28 recalls on record; FORD F 150 has 11,621 complaints and 151 recalls. Source: NHTSA owner complaints.
The numbers
Side-by-side NHTSA record
Lower is better in every category. The highlighted cell is the stronger result.
| Category | Chevrolet HHR | FORD F 150 |
|---|---|---|
| Total complaintsAll model years combined | 3,574 Better | 11,621 |
| Safety recallsFederal recall campaigns | 28 Better | 151 |
| Crash reportsCrash-related complaints | 171 Better | 330 |
| Complaints per yearAveraged across model years | 595.7 Better | 1162.1 |
| Reported injuriesTied to owner complaints | 142 Better | 297 |
| Reported deathsTied to owner complaints | 8 | 1 Better |
Source: NHTSA owner complaints & recall records.
What actually goes wrong
The problems owners report
The most-complained-about systems on each vehicle — what fails, and what owners say in their own words.
Chevrolet HHR
- 01STEERING1,562
- 02ELECTRICAL SYSTEM750
- 03AIR BAGS332
- 04FUEL/PROPULSION SYSTEM316
- 05STRUCTURE261
“There is a serious electrical glitch that's in the computer, that causes the car to perform poorly at a slow speed, which cases the steering to become very hard to turn, and maintain lanes while driving. All lights, warnings, and gauges fluctuate back and for…”
FORD F 150
- 01POWER TRAIN3,648
- 02ELECTRICAL SYSTEM2,100
- 03UNKNOWN OR OTHER1,431
- 04EXTERIOR LIGHTING1,224
- 05ENGINE880
“This lead frame issue is never ending. Well over a decade without a proper remedy. I’m very familiar with it. but this one nearly ended my life. After the near collision I called my mechanic and bought a new ford lead frame from a dealership. It’s doing fine…”
“My 2017 Ford F-150 V8 with the 6-speed automatic transmission has been experiencing a serious and recurring transmission malfunction. The truck has consistently, almost on a daily basis, gone into limp mode and become stuck in 5th gear. It also frequently fai…”
Official recalls
Safety recalls on record
Federal recall campaigns — the defect, the risk, and the fix. Confirm any open recall was completed before you buy.
Chevrolet HHR — 28 recalls
The defect: General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignitio…
The risk: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission…
The fix: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cu…
The defect: This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency o…
The risk: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
The fix: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later v…
The defect: UCI-FRAM Group is recalling certain LS1328 ignition Switches sold as Wells LS1328, Duralast LS1328, Airtex 1S6097, and Carquest 53-27479, and LS1497 Ignition Switches sold as Wells LS1497, Duralast LS1497, Airtex 1S10961, and Carquest 53-27967, for use on various General Motors model and model year…
The risk: If the ignition switch moves from the run position to accessory, the car would stall and the air bags will not deploy in the event of a crash, increasing the risk of personal injury to the occupants.
The fix: UCI-FRAM Group has notified its purchasers to quarantine and return all inventory. Any switches already installed in vehicles will be replaced by GM dealers as part of NHTSA recall 14V-047, free of charge. UCI-Fram's purchasers should cont…
The defect: General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignitio…
The risk: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission…
The fix: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cu…
FORD F 150 — 151 recalls
The defect: Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater. Water and contaminants may get into the block heater cable's splice connector causin…
The risk: When the heater is plugged in, prolonged corrosion could cause a resistive short, increasing the risk of overheated or melted wiring which can increase the risk of a fire.
The fix: Ford will notify owners, and dealers will disable the block heater cable, free of charge. Once parts are available, Dealers will replace the engine block heater cable, free of charge. The recall began June 3, 2019. Owners may contact Ford…
The defect: Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block he…
The risk: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
The fix: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The…
The defect: Ford Motor Company (Ford) is recalling certain 2015-2018 Ford F-150 Regular Cab and SuperCrew Cab vehicles. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
The risk: A vehicle fire could result if materials ignite inside the vehicle.
The fix: Ford will notify owners, and dealers will remove the B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall began September 28, 2018. Owners may contact Ford customer service at 1-…
The defect: Ford Motor Company (Ford) is recalling certain 2015-2017 Ford F-150, and 2017 F-250, F-350, F-450, and F-550 Super Duty trucks. The doors on these vehicles may have a bent or kinked actuation cable or the door latches may freeze after water gets into the latch. Either condition can result in the do…
The risk: A door that opens while driving can increase the risk of injury.
The fix: Ford will notify owners, and dealers will inspect the door latch actuation cables and repair if necessary, and install water shields over the door latches, free of charge. The recall began October 12, 2018. Owners may contact Ford customer…
Check the actual car
Comparing models is smart. Checking the VIN is essential.
Brand averages tell you the trend. A VIN check tells you what's wrong with the specific Chevrolet HHR or FORD F 150 in front of you — accident history, open recalls and title records.
Go deeper
Full reliability reports
- Comparison
- Chevrolet HHR vs FORD F 150
- Chevrolet HHR total complaints
- 3,574
- FORD F 150 total complaints
- 11,621
- Chevrolet HHR total recalls
- 28
- FORD F 150 total recalls
- 151
- Chevrolet HHR avg complaints/year
- 595.7
- FORD F 150 avg complaints/year
- 1162.1
- More reliable overall
- Chevrolet HHR
- Chevrolet HHR top complaint area
- STEERING
- FORD F 150 top complaint area
- POWER TRAIN